Tarap seed (Artocarpus odoratissimus) is one of the popular snacks among Borneo Island
people especially in Sabah, Malaysia. Their flesh and seed are such a potential food source but
they are not fully exploited. Therefore, this study was conducted to determine its nutritional
composition, mineral content and functional properties of Tarap seed flour (TSF). The
proximate analysis (protein, carbohydrate, fat, crude fiber, ash, moisture), minerals content
and functional properties (powder particle size, bulk density, oil and water absorption capacity,
emulsion capacity, foaming ability, least gelling concentration, swelling ability and pasting
properties) were determined. The proximate analysis results obtained showed that TSF had
49.65% carbohydrate, 15.60% crude fat, 12.3% crude fibers, 8.8% crude protein, 1.17 % ash
and 12.5% moisture. Most abundant mineral found in Tarap flour was potassium, followed
by magnesium, calcium, and natrium. The results showed that TSF has an average particle
size of 166.02µm with low bulk density (0.57g/cm3
) as compared to wheat flour. Water and
oil absorption capacities of TSF were 2.61 and 1.69g/g, respectively, while the efficiency of
emulsification was 14.8%. Least gelation concentration was found to be 12% while foaming
ability was 7%. Swelling ability results showed a steady increment from 60°C to 70°C but
sharp increased observed from 70°C to 80°C. From the results presented, it can be concluded
that TSF has a great potential for use in the formulation of composite flours to be used as
ingredients in the food industry.
A study to measure frying quality and stability of rice bran oil (RBO) compared to palm olein (PO) was conducted. The oils were used to fry French fries continuously for six hours a day up to five days at a temperature of 185 ± 5°C. Oil samples were collected and analyzed for free fatty acid (FFA), peroxide value (PV), smoke point, p-anisidine value (p-AV), iodine value (IV) and colour. At the end of the frying period for both oil samples, FFA, PV, colour and p-AV were increased whereas the IV and smoke point decreased. The rate of FFA formation of RBO was slightly lower which increased from 0.142% to 0.66% compared to PO which was from 0.079% to 0.93%. The PV of RBO showed consistent increased from 3.9 meq/kg to 13.4 meq/kg whereas PO with initial value at 3.4 meq/kg increased to 34.6 meq/kg on the fifth day. Smoke point of RBO and PO progressively dropped from 235°C to 188°C and 220°C to 178°C, respectively. The level of p-AV for RBO increased from 12.19 to 32.65 from the initial to the end of frying day whereas PO had higher rate of changes in p-AV which was from 10.45 to 60.75. The IV decreased over frying time where IV of RBO decreased from 94.5 to 66.5 while IV of PO decreased from 50.9 to 44.6. The colour of RBO showed increased in redness and yellowness but PO was darker at the end of the frying trial. In general, RBO showed better stability than the PO in deep frying of French fries.
Clinacanthus nutans (Burm. F.) Lindau or locally known in Sabah, Malaysia as ‘Sabah Snake Grass’ has been ethnobotanically used to treat various diseases in Asian countries. This study was conducted to determine the total phenolics content (TPC), flavonoids content (TFC) and antioxidant activity of herbal teas developed from C. nutans leaves with different drying techniques (microwave-oven dried and freeze dried) and infusion time (1, 2, 5, 10, 15 and 20 min). Ferric reducing/antioxidant power (FRAP) assay, 2,2’-azino-bis(3-ethylbenzothiazoline- 6-sulphonic acid (ABTS) and 2, 2-diphenyl-1-pycryl-hydrazyl (DPPH) free radical scavenging assays were used to investigate the antioxidant capacity. The highest TPC of herbal tea was observed in 20 min infusion of unfermented microwave-oven dried leaves (177.80 ± 19.10 mg TAE/L), while the highest TFC was observed in 10 min infusion of fermented microwave-oven dried leaves (22.13 ± 1.53 mg CE/L). Short infusion times from 5 min to 15 min were able to extract high amount of phenolics compounds. Unfermented tea contained higher TPC content (P < 0.05) as compared to fermented tea, while, TFC showed no significant difference between both types. Freeze dried infusion shows no significant difference (P > 0.05) as compared to microwave-oven dried for TPC, TFC and antioxidant capacity. Moderate and low correlation was observed between TPC and FRAP values (r = 0.507) and between TFC and ABTS values (r = 0.256). Preparation of C. nutans herbal tea as potential natural antioxidant source can be used as a basic reference for future research on the dietary intake of these herbal teas.
The development of food products using composite flour has increased and is attracting much attention from researchers, especially in the production of bakery products and pastries. This article focuses on the use of composite flour to produce food products, namely bread, biscuits, and pasta, with looks at on its impact, following some improvements made, on the sensory quality, rheology characteristics, and nutritional values as well as its overall acceptance. The blending of wheat flour with various sources of tubers, legumes, cereals and fruit flour in different percentages to produce variety of food products are also reported in this review. It was found that composite flour used to produce food products is still able to maintain similar characteristics to products made from full-wheat flour. The positive effects of the use of composite flour can be seen in the final product related to the functional and physicochemical properties and health benefits of raw blended flour along with percentage blending. Overall, composite flour is a good new approach to utilizing uncommon food products as the application of composite flour produced products with different characteristics and quality, depending on the types and percentage of wheat flour used in the formulation.
Supercritical carbon dioxide (scCO2) extracted mango seed fat (MSF) was blended with palm oil mid-fraction (POMF) to obtain cocoa butter replacers (CBRs). The fatty acid constituents and physicochemical properties of the formulated blends were analysed by gas chromatography (GC). In this study, the fatty acid constituents and other physicochemical properties such as iodine value (43.2 to 43.4 g I2/100 g fat), saponification value (195.7 to 195.9 mg KOH/g fat), acid value (2.1 to 2.7%), and slip melting point (33.8 to 34.9°C) of blends MSF/POMF at ratios 85/15, 80/20, 75/25, and 70/30 were found similar to the physicochemical properties of commercial cocoa butter. Thus, it could be concluded that the MSF/POMF blends that are blends 85/15, 80/20, 75/25, and 70/30 (3 to 6) could be suggested as CBRs in terms of the physicochemical properties like fatty acid constituents, iodine, saponification and acid values and slip melting point.
In this work, the effect of solvent pre-treatment (hexane, petroleum ether and ethanol) on the physicochemical, thermal and morphology behavior of Mangifera pajang seed fat (MPSF) were investigated. Fat extraction was performed using Soxhlet method, and results showed that the yield, physicochemical, and crystalline structures of the MPSF were significantly (p < 0.05) influenced by the extraction solvents. Hexane gave the highest fat yield (7.67 %) with low unsaturation value (52.13 g iodine/g) compared with petroleum ether and ethanol. Hexane MPSF also had low oxidation rate (peroxide value of 1.1 mEq/g). Both non-stabilized and stabilized hexane MPSF showed a single melting endothermic peak at high temperature with onset, maximum peak and offset temperature of 16.23 ˚C-18.21 °C, 28.22 ˚C-31.25 °C and 34.85 ˚C-39.58 °C, respectively. Hexane MPSF crystallized rapidly at high temperature with single maximum peak starting at 16.51 ˚C-16.68 °C and ending at 0.23 ˚C-1.13 °C. In comparison with ethanol extract, hexane MPSF demonstrated a compact crystalline structure with a large densely packed center. Therefore, MPSF obtained from hexane presented better overall quality than those obtained from other extraction solvents. MPSF exhibited similar melting and morphological behavior to mango kernel fat and commercial cocoa butter. These results suggested that hexane was the best solvent for the extraction of MPSF. This fat also has the potential to be applied as a cocoa butter alternative fat or functional fat.
Fruits are important food commodities that can be consumed either raw or processed and are valued for their taste, nutrients, and healthy compounds. Mangifera pajang Kosterm (bambangan) is an underutilized fruit found in Malaysia (Sabah and Sarawak), Brunei, and Indonesia (Kalimantan). It is highly fibrous and juicy with an aromatic flavour and strong smell. In recent years, bambangan fruit has been gaining more attention due to its high fibre, carotenoid content, antioxidant properties, phytochemicals, and medicinal usages. Therefore, the production, trade, and consumption of bambangan fruit could be increased significantly, both domestically and internationally, because of its nutritional value. The identification and quantification of bioactive compounds in bambangan fruit has led to considerable interest among scientists. Bambangan fruit and its waste, especially its seeds and peels, are considered cheap sources of valuable food and are considered nutraceutical ingredients that could be used to prevent various diseases. The use of bambangan fruit waste co-products for the production of bioactive components is an important step towards sustainable development. This is an updated report on the nutritional composition and health-promoting phytochemicals of bambangan fruit and its co-products that explores their potential utilization. This review reveals that bambangan fruit and its co-products could be used as ingredients of dietary fibre powder or could be incorporated into food products (biscuits and macaroni) to enhance their nutraceutical properties.
The objective of this study was to optimize the extraction of oil from pre-dried roselle seeds using response surface methodology (RSM). We also determined the oxidative stability of oil extracted from oven and freeze-dried roselle seed in terms of iodine value (IV), free fatty acid (FFA) value, peroxide value (PV), P-anisidine and total oxidation values (TOTOX value). The RSM was designated based on the central composite design with the usage of three optimum parameters ranged from 8 to 16 g of sample weight, 250-350 mL of solvent volume, and 6-8 h of extraction time. The highest oil yielded from roselle seed using the optimization process was 22.11% with the parameters at sample weight of 14.4 g, solvent volume of 329.70 mL, and extraction time of 7.6 h. Besides, the oil extracted from the oven dried roselle seed had the values of 89.04, 2.11, 4.13, 3.76 and 12.03 for IV, FFA, PV, P-anisidine, and TOTOX values, respectively. While for the oil extracted from freeze-dried roselle seed showed IV of 90.31, FFA of 1.64, PV of 2.47, P-anisidine value of 3.48, and TOTOX value of 8.42. PV and TOTOX values showed significant differences whereas; IV, FFA, and P-anisidine values showed no significant differences between the oven and freeze-dried roselle seed oils.